Mono Bx OVEN Spécifications

CLASSIC COLOUR Bx OVEN SET UP AND OPERATION OF OVEN AND CONDENSER UNIT (IF FITTED) OVEN SERIAL NO. FG CODE 149 150 153 15

6.0 CLEANING INSTRUCTIONS DAILY NOTE: BEFORE CLEANING ISOLATE OVEN FROM MAINS SUPPLY AND ALLOW TO COOL. x The equipment is to be cleaned daily

Ovens using 60cm x 40cm trays ( FG156 2 tray / FG158 4 tray) Open oven door and remove internal racking from sides of oven. (lift and unlatch rackin

Bx oven range inc condenser 05-06 (12-07) RAC 127.0 IDEAL OPERATING CONDITIONS x Room should be allowed for the door to open fully to allow easy lo

Bx oven range inc condenser 05-06 (12-07) RAC 13Bx CLASSIC Operating Instructions CLASSIC

8.0 BX‘CLASSIC’ OPERATING INSTRUCTIONS RUNNING PRE-SET PROGRAMS Bx oven range inc condenser 05-06 (12-07) RAC 14REFER TO CONTROL PANEL (SEE R

9.0 BX 'CLASSIC' PROGRAMMING INSTRUCTIONS CREATING PROGRAMS/CHANGING PROGRAM VALUES.Bx oven range inc condenser 05-06 (12-07) RAC 15Pre-

Bx oven range inc condenser 05-06 (12-07) RAC 16Bx COLOUR Operating Instructions COLOUR

Bx oven range inc condenser 05-06 (12-07) RAC 17FAN DWELL PROGRAM NAME TEMPERATURE GRAPH BAKE TIME GRAPH ½ OR FULL BAKEOVEN TEMPERATUREB

Bx oven range inc condenser 05-06 (12-07) RAC 1810.0 BXC OPERATING INSTRUCTIONS 1. Connect water ensuring there are no leaks. 2. Connect power

Bx oven range inc condenser 05-06 (12-07) RAC 196. Start heating oven by pressing (4) for ½ load bake and (1) for full load, and the followin

Bx oven range inc condenser 05-06 (12-07) RAC 2Bx oven range inc condenser 05-06 (12-07) RAC 2

Bx oven range inc condenser 05-06 (12-07) RAC 20 9. This will now take you back to program screen (Fig 2). 10. To bake in pre-heated oven, select

Bx oven range inc condenser 05-06 (12-07) RAC 2111.0 BXC PROGRAMMING INSTRUCTIONS 1. Press stop (o) to get to first screen 2. Press (2) fo

The oven is capable of six different phases per bake and if a lower number is required, bake time can be left at “0” to leave that phase inoperative.

12.0 USING MONOLINK UPLOAD/DOWNLOAD SYSTEM SOFTWARE Equipment required: P.C. floppy disk drive 9 ways D-type serial port Windows 95-2000

Section 2. Setting up 1. Choose ‘Configure’ and scroll down to ‘Com port’ 2. Then click on ‘Com 1’ oven type 3. Next click on ‘Configure’ scroll

Section 4. Saving Click on ‘file’ then scroll down to ‘save as’ and click on it, and the following box will appear, chose an appropriate drive and e

Section 6. Transferring files from your PC to your smartbake controller Before any file transfer can take place the folder you wish to transfer file

If during either uploading or downloading, the communications error window opens, With the error message “Error in reply from controller” then che

13.0 MAINTENANCE x Check for frayed or bare cables. The machine must not be used if frayed or bare cables are visible. x Follow cleaning i

Bx oven range inc condenser 05-06 (12-07) RAC 29 CONDENSER UNIT

ATTENTION IF OVEN FAILS TO HEAT UP WHEN FIRST CONNECTED TO A POWER SUPPLY OR DURING USE AT ANYTIME, PRESS RESET BUTTON(S) LOCATED INSIDE THE REAR

INTRODUCTION PAGE 31 DIMENSIONS PAGE 32 SPECIFICATIONS PAGE 33 INSTALLATION PAGE 34 SAFETY PAGE 36 OPERATION PAGE 37

The condenser can be fitted to any Bx oven or stacked Bx ovens as required. With thermostatic control it can be adjusted to operate in most ambia

Bx oven range inc condenser 05-06 (12-07) RAC 32DIMENSIONS

Bx oven range inc condenser 05-06 (12-07) RAC 33SPECIFICATIONS POWER 230volts, 1 phase, 50hz, 21w

1. Before fitting the main condenser assembly, insert blanking plug (1) into lower hole that will not be requi

3. Place condenser in position ensuring that the tube (2) passes through the hole in the top of the oven and worm drive clip (4), then over spigot of

1. All repairs and maintenance of electrical units must be carried out by authorised electricians; even then, electrical access panels must

1. Ensure that the water is connected correctly and the oven power is on. 2. The thermostat control should

Bx oven range inc condenser 05-06 (12-07) RAC 38SPARES INFORMATION FOR ENGINEERS USE ONLY. DO NOT ATTEMPT ANY ALTERATIONS. IF IN DOUBT, CONTACT MONO

Bx oven range inc condenser 05-06 (12-07) RAC 39CONDENSER UNIT MAIN PARTS

Bx oven range inc condenser 05-06 (12-07) RAC 4CONTENTS PART 1.0 Introduction 5 PART 2.0 Specifications 6 PART 3.0 Safety

ITEM PART No. DESCRIPTION QTY 1 150-07-01300 INLET WATER CONTROL UNIT 1 2 150-19-01700 TOP SHEET 1 3 150-19-0230

Bx oven range inc condenser 05-06 (12-07) RAC 41 THIS SECTION ONWARDS IS FOR TRAINED SERVICE ENGINEERS INSTALL

Bx oven range inc condenser 05-06 (12-07) RAC 51.0 INTRODUCTION x A combination of clean industrial design

Bx oven range inc condenser 05-06 (12-07) RAC 62.0 SPECIFICATIONS

Bx oven range inc condenser 05-06 (12-07) RAC 7 3.0 SAFETY In the interest of safety and efficient operation of the oven, it is essential that

Bx oven range inc condenser 05-06 (12-07) RAC 8 1. The oven should be connected to a wall isolator. 4.0 INSTALLATION

5.0 ISOLATION ELECTRICITY SUPPLY To stop the oven in an emergency, switch off electricity at the wall isolator. WATER SUPPLY For stacked